[RE-wrenches] Enphase data interference

[William Miller]

Larry:

Thanks very much.  I am gong to do what you recommend.  By the way, the 
interference is said to be at about 144kHz.  Do these cap values seem to be 
relevant at that frequency?

WM

At 01:31 PM 9/25/2012, you wrote:
>Hello William,
>
>Since you have identified the cause, look to filtering the RFI at the 
>source, it will be easier than trying to keep it out of your Envoy. I 
>would start with AC line capacitors. Solder a 0.1uF ceramic cap from 
>leg~leg and leg~ground as close to the motor as you can, keeping leads 
>short. Do the same at the AC input and output to the motor controller if 
>it has one. Make sure the motor frame has a good ground. If possible, make 
>sure that your PV system, monitor and the pond motor are at the same 
>ground potential.
>
>Note: If a line voltage surge occurs, these caps will likely burn or 
>explode (small scale) so, with this in mind, be aware of placement.
>
>I can tell you from many years experience as an amateur radio weak signal 
>operator, detection and reducing RFI issues are a mix of science and art. 
>You may want to contact your local Ham Radio club and see if they can 
>recommend someone that is willing to help.  Good luck!
>
>Larry Crutcher
>Starlight Solar Power Systems
>
>
>
>
>On Sep 24, 2012, at 5:47 PM, William Miller wrote:
>
>Friends:
>
>Just a heads up for those of you installing Enphase systems:
>
>After installing over a dozen systems we came up with a job where we have 
>been unable to resolve interference issues.  The problem is receiving data 
>from the inverters into the Envoy.  We have tried relocating every 
>component, using multiples of the ferrite beads, various models of X10 
>filter modules, etc.
>
>Enphase has been trying their best, remotely, to help resolve the problem 
>but without success.  The interference is being caused by an expensive 
>pond pump (or we would have a new one by now).  We are awaiting an AC 
>filter module from Digi-key.  I will let you all know how it turns out.
>
>In the meantime, I have added the following paragraph to my contracts:
>
>         Data systems: Some new inverter systems transmit data over your 
> power lines.  On rare occasion interference from your appliances will 
> occur that block this data transmission.  We can resolve these problems 
> but there may be extra charge for our time and materials.
>
>My profit from this job has evaporated.  I am writing this because I don't 
>want to see any of you in this situation unknowingly.
>
>More later,
>
>William Miller
>
>Miller Solar
>Voice :805-438-5600
>email: <mailto:william at millersolar.com>william at millersolar.com
>http://millersolar.com
>License No. C-10-773985
>_______________________________________________
>List sponsored by Home Power magazine
>
>List Address: 
><mailto:RE-wrenches at lists.re-wrenches.org>RE-wrenches at lists.re-wrenches.org
>
>Options & settings:
><http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org>http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org
>
>List-Archive: 
>http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org
>
>List rules & etiquette:
>www.re-wrenches.org/etiquette.htm
>
>Check out participant bios:
>www.members.re-wrenches.org
>
>
>_______________________________________________
>List sponsored by Home Power magazine
>
>List Address: RE-wrenches at lists.re-wrenches.org
>
>Options & settings:
>http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org
>
>List-Archive: 
>http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org
>
>List rules & etiquette:
>www.re-wrenches.org/etiquette.htm
>
>Check out participant bios:
>www.members.re-wrenches.org
>
>
>Internal Virus Database is out of date.
>Checked by AVG - www.avg.com
>Version: 8.5.455 / Virus Database: 271.1.1/5272 - Release Date: 09/16/12 
>18:34:00

Miller Solar
Voice :805-438-5600
email: william at millersolar.com
http://millersolar.com
License No. C-10-773985
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org/attachments/20120925/090a9e1e/attachment-0003.html>